Toyota Fuel Cell Hybrid Achieves 431-Mile Estimated Range
TORRANCE, CA - In a recent field evaluation, the Toyota Highlander Fuel Cell Hybrid Vehicle - Advanced achieved an estimated range of 431 miles on a single full tank of compressed hydrogen gas.


TORRANCE, CA - In a recent collaborative fuel cell hybrid vehicle range and fuel economy field evaluation, the Toyota Highlander Fuel Cell Hybrid Vehicle - Advanced (FCHV-adv) achieved an estimated range of 431 miles on a single full tank of compressed hydrogen gas, and an average fuel economy of 68.3 miles/kg (approximate mpg equivalent) during a day-long trip down the southern California coast.
In mid-2008, the U.S. Department of Energy (DOE), Savannah River National Laboratory (SRNL), and the National Renewable Energy Laboratory (NREL) approached Toyota to participate in a collaborative evaluation of the real world driving range of the FCHV-adv. On June 30, two fuel cell vehicles, two Toyota Technical Center engineers, an SRNL engineer, and a NREL engineer completed a 331.5 mile extended roundtrip drive between Toyota Motors Sales U.S.A. headquarters in Torrance, Calif., and San Diego.
The route encompassed a variety of drive cycles, including high speed highway driving, moderate highway driving and stop and go traffic on surface streets, in an effort to capture a typical commute. Each vehicle was outfitted with a data collection system that captured vehicle speed, distance traveled, hydrogen consumed, hydrogen tank pressure, temperature and internal tank volume.
Driving range data from each vehicle was calculated by SRNL and NREL engineers. The results were averaged for an estimated range of 431 miles, with an average fuel economy of 68.3 miles. The FCHV-adv is estimated to travel approximately 68 miles at a projected cost of about $2.50 - more than double the range of the Highlander Hybrid, at equal or lesser cost, while producing zero emissions.
SRNL and NREL analyzed all data gathered during the evaluation and prepared a formal report to DOE verifying range results and miles per kilogram achieved. The report will assist regulators and government research programs to accurately assess the status of the fuel cell industry and viability of the current technology.
"Toyota's hydrogen fuel cell technology has advanced rapidly over the last two years," said Irv Miller, TMS group vice president, environmental and public affairs. "In 2015, our plan is to bring to market a reliable and durable fuel cell vehicle with exceptional fuel economy and zero emissions, at an affordable price."
More Fuel
Turning Fleet Payment Data into Executive Insights
Ramel Lindsay of U.S. Bank Voyager discusses how fleets can transform payment and transaction data into actionable intelligence to reduce costs, improve oversight, and support executive decision-making.
Read More →
Why the IRS Raised Its Mileage Rate in the Middle of 2026
Fuel-price volatility drove the rare increase to 76 cents per mile, the fifth midyear adjustment since 2000.
Read More →
July Fuel Update: Prices Keep Rising in Light of More Conflict
Gas prices continue to rise as more and more conflicts do, too.
Read More →
Bob Adamsky on Fuel Volatility: "Don't Panic, Have a Plan."
When it comes to up and down fuel prices, Adamsky has a message for fleets: “Don’t panic.”
Read More →
How Fleets Can Gain Control of Non-Fuel Spend
Fuel often gets the spotlight, but non-fuel expenses can have a major impact on fleet costs. Ramel Lindsay of U.S. Bank Voyager discusses how fleets can gain better visibility and control over these often-overlooked expenditures.
Read More →
Fuel is Just the Start: How Middle East Tensions are Driving Up Fleet Maintenance Costs
The Middle East conflict is doing more than pushing up fuel prices. It’s also raising the cost of key maintenance products your fleet depends on, from motor oil to tires to windshield wipers. Here’s what you need to know about this budget-busting situation.
Read More →
June Fuel Update: Prices Fall Below $4
Drivers are finally getting some relief at the pump. The national average gas price has dropped below $4 a gallon for the first time in months, with prices falling in 47 states as oil markets react to developments in U.S.-Iran negotiations.
Read More →
Study: How 2026's Gas Price Hikes Affect Different Vehicle Types
New data from iSeeCars reveals how rising fuel costs have affected different vehicle segments as gasoline prices climbed nearly 46% over the past four months.
Read More →Are You Tracking Your Fleet's True Total Cost of Ownership?
Bobit Business Media surveyed 190 fleet professionals and found that while most fleets are tracking costs, fragmented systems and data gaps are keeping true TCO visibility out of reach. With rising pressure to control spend in an increasingly volatile environment, the gap between what fleets think they know and what the data actually shows is wider than you might expect. See how your peers are managing costs today and where the industry still has room to improve.
Read More →
May Fuel Update: All Regions Experience Declines
Gas prices are finally easing in much of the country, but experts warn global tensions could quickly reverse the trend as the national average remains well above last month’s levels.
Read More →